Power Transmission Corporation Of Uttaranchal Limited

Power Transmission Corporation Of Uttaranchal Limited has published Replacement Of Tower No 18 B 6 Of 132Kv Bindal Rishikesh Majra Line In Bindal River Dehradun , Supply , Hot Dip Galvanized Stub , Hot Dip Galvanized Stub Nut & Bolt , Supply Of 132Kv Hot Dip Galvanized Steel Lattice Single Circuit Standard Tower And Their Extension Tower ( 01 No. C+6 Type Tower ) As Per Approved Drawing And Technical Specification As Required For Proper Erection Of Tower , Hot Dip Gi Nut, Bolt, Washer And Step Bolts For Tower As Per Approved Drawing And Technical Specification As Required For Proper Erection Of Tower = ( 0.43036X1 ) , Acsr Panther Conductor Allowing 1.5% Sag, Jumpers And Wastage Etc As Per Approved Technical Specification , 7 / 10 Swg G.S Earth Wire As Per Approved Technicalspecification , Galvanized Template Of C Type Tower , Fitting And Accessories , 120 Kn Disc Insulator For Tension Fitting. , Single Tension Fitting ( 120 Kn ) Foracsr Panther Conductor. , Vibration Damper For Acsr Panther Conductor. , Tension Fitting For 7 / 10 Swg G.S Earth Wire. , Vibration Damper For Earth Wire , Mid Span Compression Joint For Acsr Panther Conductor. , Mid Span Compression Joint For Earthwire. , Tension Clamp For 7 / 10 Swg Earth Wire , Repair Sleeve For Acsr Panther Conductor. , Bonding Pieces ( Copper Bond ) , Danger Plate , Number Plate , Phase Plate Set , Ms Bar Different Size ( 16 & 12 Swg ) For Foundation Of Towers , Pipe Type Earthing Set ( Set Of 02 No. For Each Tower ) , Anti Climbing Device Barbed Wire , Bird Guards , Erection , Detail Survey To Ascertain Tentative Route And Appoximate Length Of Line Span. Tower Quantities, Type Of Tower, Preparation Of Schedule Of Matrerial, Check Survey, Peg Marking Of Location, All Imporatant Feature And Instructions Like Uneven Level, Rivers, Roads, Ponds, Forests Inhibited Areas, Power Telecom Lines Etc, 50 Meters On Either Side Of The Line Route Shall Be Duly Marked. The Features Mentioned Above Shall Be Duly Considered Providing Adequate Clearances, Levels And Angles Must Be Plotted On The Profiles, Towers And Height Of The Towers Sag Template Tower Spotting Are Marked At Different Spans. Just Below The Tower Spotting The Ground Profil Is Also Drawn. Sag Tension Calculations Must Be Taken Care Of Creep Of Conductor Used. , Detailed Soil Investigation In All Type Soil Per Location , Work Of Dismantling Of Old 132Kv Bindal-Rishikesh Dctower No.18 B+6 ( 7.0Mt ) As Per Direction Of Ptcul Representative. , Setting Of Stubs, Including All Foundation Work But Excluding The Cost Of Concreting And Excavation. ( 02 No. C+6 ) Towers. , Earth Work In Excavation By Mechanical Means ( Hydraulic Excavator ) / Manual Means In Foundation Trenches Or Pits Of Any Size, Including Dressing Of Sides And Ramming Of Bottoms, Including Getting Out The Excavated Soil And Disposal Of Surplus Excavated Soil As Directed, Including All Leads & Lifts. , Providing And Laying In Position Specified Grade Of Reinforced Cement Concrete, Including The Cost Of Centering, Shuttering, Finishing. All Work Up To Plinth Level : 1:1.5:3 ( 1 Cement : 1.5 Coarse Sand : 3 Graded Stone Aggregate 20 Mm Nominal Size ) . , Back Earth Filling After Completing Of Foundation Work With Ramming, Curing Etc Including All Labour And T&P Etc. , Lowering Of All 03 Phase No. Acsr Panther Conductor To Ground Fromtower No. 17B To 19B 132Kv Bindal-Rishikesh, Anchoring Of 03 Nos. Conductor Including Making Coil To Make Ease To Load In Truck. , Lowering Of All Earth Wire To Ground From Tower No. 17B To 19Bof 132Kv Bindal-Rishikesh Lineanchoring Of Earthwire Including Making Coil To Make Ease To Load In Truck. , Erection Of Superstructure Standard Tower And Their Extension Tower ( 01 No. C+6 ) Type Towerincluding All Work Above Ground Level, Excluding Hoisting Of Insulators And Fitting Of Danger, Number, Phase Plate Including Punching Of Bolts. , Work Of Strengthening Of Towers By Providing Stays To All Three Cross Arm With The Help Of Steel Rope And Turn Buckleat Suitabledry Place Near Tower, Including Excavation Of Earth, Grouting Of Stay With All Necessary Work Required In Order To Ensure Safety Of Next Tower To Prevent From Any Distortion And Safe Desagging Of Three Line Conductors And Earthwire. , Laying, Stringing, Tensioning, Clamping, Jointing Etc Complete With Acsr Panther Conductor ( Tower No. 17B To 19B Of 132Kv Bindal-Rishikesh Including Hoisting Of Insulators And Fitting Dampers And All Accessories For Complete Route Of All The Three Power Conductors. , Laying, Stringing, Tensioning, Clamping, Jointing Etc Complete With Earth Wire ( ( Tower No. 7B To 9B And 17B To 19B 132Kv Bindal-Rishikesh ) Including Hoisting Of Insulators And Fitting Dampers And All Accessories For Complete Route Of All The Three Power Conductors. , Pipe Type Earthing ( Set Of 2 No. For Each Tower ) Including Cost Of All Material Per Specification , Tack Welding On Bolts And Nuts On First Section Of Tower , Fixing Of Number Plate, Phase Plate And Danger Plates Etc , Anti Climbing Device Barbed Wire , Bird Guards ( Set Of Six ) , Cartage Of New Tower Parts Conductor, Earthwire And Its Accessories From Store Bindal To Site And Shifting Of Dismantled Conductor And Earth Wire Etc From Site To Store Bindal Including Head Loading And Unloading Etc , Consultancy Charges For The Work Designing Of Special Foundation For Tower In Bindal River And Vatted From Iit Roorkee / Bombay / Bhu @ 2%Total ( A+B ) . Last date of submission for this tender is 2022-07-07. This is a Earth Moving Machinery tender in Dehradun, Uttarakhand