Urban Development And Housing Department

Urban Development And Housing Department has published Bids Are Invited For Street Light Sitc Of 08 Mtr. - Special Box Type Poles With Integrated Led Lights In Box Type Bracket & Other Accessories At Jambusar Nagarpalika-1 63 Supplying & Erecting Modern Decorative Square Street Light Pole Having 8Mtr. Height Made From 150Mm X 150Mm X 4Mm Ms Pipe ( Tolerance As Per Is ) Heavy Base Plate With Support Stifners Thickness 10Mm & With Base Plate 300Mmx300x16mm For Suit. Suspend Local Wind Speed. The Pole Should Be Made As Per Is And Shall Be Coated With Sand Blasting One Coat Of Pu Primer Spray And Two Coat Of Pu Glossy Paint Spray At Site With Intergral Junction Box 500Mm Long With Chain Consist Of Terminal Plate Of Min. 5Mm Hylam Sheet , Standard Profile 35Mm X 7.5Mm Din-Rail With 02 Nos. 2A Sp Mcb Mounting 50A Heavy Backelite Connector And Stud Type Terminal And Arrangement For Cable Termination And Earthing Connections. Work As Instruction Of Engineer In Charge - Pole Length 8Mtr. ( Market Rate ) No. 2 126 Supplying And Erecting Decorative Type Square 150W Ip65 Led Streetlight Fittings Made With 1.15 Mtr. 150Mm X 150Mm Square Gi Housing Erection Support Arm Bracket Made From 5Mm Plate And 16Mm Square Bar With Pu Paints ( Pu Match With Street Light Pole Pu Paints ) And Internal Led Streetlight With High Power White Leds Wattage Of 4 To 5W And Above Assembled On Mcpcb As Per Requirement, Effeciency More Than 130Lm / W And Corrosion Free High Pressure Die Cast Alluminium Housing Size Not More Than 120Mm Width And Length 750Mm With Smooth Finish Powder Coated And Heat Shrink Extruded Aluminium With Diffuser And Polycarbonate Optics / Lenses With Company Mark / Name Engraved Or Embossed, Operating Voltage Cut Off 120V To 300V + / - 1%, Restart Voltage 277V, With 16Kv Surge Protection, Power Factor More Than 0.95, Thd <10%, Cct 4000K To 5700K, Uniformity Ratio >0.45 Luminare Efficiency >115 Lumens / Watt Led Driver Efficiency>85%. Cree / Osram / Phipplips Lumileds / Nichia / Seoul / Bridgelux ( Usa ) Make Led Usded For Luminare ( Fittings Required Lm-79 & Lm-80 Certificates ) ( Note : Fixtures Will Be Tested At Erda / Nabl Approved Lab Fitting Must Be Erected On Pole After Pole Erected On Foundation. ) - ( Market Rate ) No. 3 63 Providing Providing M-150 / 1:2:4 Cement Concrete Foundation & 70 % Pcc From Bottom Including Excavation For The Pole Of Size 60 X 60 X 120 Cms. Deep In Below Ground Level With Plinth Of 45 Cms X 45 Cms ( Or 45 Cms Dia X 45 Cms ) High Upper Ground Level With Necessary Curing And Finishing In Approved Manner. ( For 8.0 Mtr Pole ) ( Sor It. No. 6-3-5 ) No. 4 126 Providing And Erecting Miniature Circuit Breaker Single Pole 0.5A To 2A System And Having Breaking Capacity 10 Ka To Be Erected In Existing Box. Confirming To Is 8828 / 1996 With Isi Mark ( Sor It. No. 3-10-1 [ A ] ) No. 5 520 P & F Of Solderless Crimping Type Aluminium Lugs ( 4 Nos. Per Termination ) Conforming To Is Suitable For 1 X 4.0 Core X 16 Sq. Mm Pvc Insulated Aluminium Armoured Cablewith High Pressure Tool &L Complete Erected With Insulating Materials For Each Pole - 08 Nos. ( Sor It. No. 4-7-1 [ C ] ) No. 6 63 Sitc Of Pipe Type Earthing Having 150 Cms.Long And 2.5 Cms. Dia. Galvanised Iron Pipe With Coupling And Buch Buried In Specially Prepared Earth Pit Complete With Necessary 8 Swg Earth Wire.- ( 1 No Per St. Light Pole ) ( Sor It. No. 3-14-6A ) No. 7 1260 Supplying & Erecting Xlpe ( Is:7098 ) ( I ) -88 Isi Unarmoured Copper Cable 1.1 Kv Grade To Be Erected As Directed Having Size 3 Core 2.5 Sq.Mm ( Sor It. No. 4-2-1E ) Rmt. 8 2000 Providing, Laying, Testing & Commissioning Of 1 X 4.0 Core X 16 Sq. Mm, Xlpe ( Is: 7098 ( I ) - 88 ) , Isi Mark, Armoured, Multistranded, Aluminium Conductor Suitable For 1.1 Kv Grade To Be Laid 90 Cms Under Ground Or To Be Laid On Wall With Necessary Clamps Or In Existing Cable Trench / Pipe At Road Crossing Or On Floor And Making The Ground As Per Original. - For Streetlight Between Two Poles & Service Connections. ( Sor It. No. 4-3-5 [ A ] ) Rmt. 9 2000 Providing & Laying Of Approved Make 50 Mm Nominal Od Doubled Walled Corrugated Pipes ( Dwc ) Of Polyethylene ( Conforming To Is 14930 - Ii ) With Necessary Connecting Accessories Like Coupler, Tee, L - Bow, Etc. Of Same Material At Required Depth ( 90 Cms ) Including Excavation For Laying Of Cable Below Ground / Road Surface For Enclosing Cable And Back Filling The Same To Make Ground As Per Original & For Streelight Cable Of 1 X 4 Core X 16 Sq. Mm And Service Cable Of 1 X 4 Core X 16 Sq. Mm. ( Sor It. No. 4-5-8 ) Rmt. 10 2 Supplying & Erecting Ip 55 Grade Following Size Section Pillar Fabricated From Joint Less M.S. Sheet With Angle Iron Legs Made From Jointless M.S. Angle With Cable Clamps To Be Buried In Ground To Have Appropriate Erection To Work Uniform Until Erected With Cement Concrete Foundation And 45 Cms High Bricks Work Finishing With Plaster Etc. Hinged Double Door Internally Supported On Both Side, With Internal And Outside Looking Arrangement With Look And Keys In Duplicate 35 X 35 X 5 Mm M.S. Angle Of Two Nos. One Is Welded And Other With Nut And Bolt For Erecting Bakelite Sheet. Painting The Section Pillar Inside And Out Side With Three Tank Powder Coated Paint. Section Pillar Roof Should Be Without Joint With Water Leakage Proof & Tested As Per Ip 55 Test & Followed By Is 2147 Of 1962 ( A ) 150 X 90 X 75 Cm Section Pillar Fabricated From 14 Guage Ms Sheet With Angle Iron Legs 95 Cms Long Made From 40 X 40 X 6 Mm Thick Ms Angle. ( Sor It. No. 6-6-1 [ A ] ) No. 11 2 Supplying & Erecting Approved Make Digital Time Switch Having Lithium Cell 6 Years Operative And Operate Battery Backup 1 Channel Day Clock With 14 Memory Programme, Suitable To Operate On 240V + 5%, 16A With, Floating Contacts Minimum Switching Setup Time 1 Minimum & Lcd Display. Also Comprised Permanent On / Off Switching. Programming Switches & Housed In Fire Proof Thermoplastic Enclosure & Transparent Cover Erected As Required With Necessary Connection Erected As Directed. ( Sor It. No. 6-7-2 ) No. 12 2 Supplying & Erecting Power Contactor For Time Switch Complete Erected As Per Direction Cat Iii [ D ] 4 Pole 440V 40 Amp. ( Sor It. No. 6-7-5 ) No. 13 2 Approved Make Four Pole Moulded Case Circuit Breaker Having Breaking Capacity Icu Of 25 Ka. At 415 V, Having Normal Current Rating Up To 25 A To 100A. With Fixed Thermal & Magnetic Release Suitable To Work On A.C. Supply 50 C / S. With All Internal Connections & Complete Erected In Existing 16 G.M.S. Housing. ( Sor It. No. 3-4-1 ) No. 14 2 Supplying & Erecting Funnel Type Earthing Having 60 Cms X 60Cms X0.315 Cms 300600 Mm X 600 Mm X 3.15 Mm Thk. Copper Earth Plate Burried In Specifically Prepared Earth Pit 3 Intr. Below Ground With 40 Kg. Charcoal And 40 Kg. Salt With Alternate Layers Of Charcoal & Salt, 20 Mm Dia Medium Class G. I. Pipe With Funnel With A Wire Mesh For Watering & Bricks Massanary Block, C. I. Cover Complete As Per Para 7.3 Of Is: 3043 With Necessary Length Of Double Galvenised Copper Earth Wire No. 6 Swg - Bolted With Lugs To The Plate And Covered In 12 Mm Dia. G. I. Pipe - 2.5 Mtr. Long Complete Connected To The Nearest Switch Gears With End Socket As Per Direction & Duly Tested By Earth Tester Confirming To Is & As Per Drawing - ( 1 Job Per Distribution Box ) ( Sor It. No. 3-14-12 [ C ] ) No. 15 150 Drilling The Road & Gate Witout Breaking The Road & Gate Surface ( Asphalt ) For Laying Of Cable For Feeding Power Supply By Making Up To 100 Min Bore Dia Of Hole At Both End Complete. ( Sor It. No. 4-5-4 ) Total Quantity : 6381. Last date of submission for this tender is 2023-02-25. This is a Couplers tender in Bharuch, Gujarat